DIY Pot Handle Potholders

Projects

I am back to making potholders. Now that my pot lids are cozy, I decided my pot handles should be dressed as well. I drafted a pattern and made it in two ways. The first way I tried has a band to finish off the edges. The second and easier version has the edge finished first. I will give directions for both. My favorite is the second version. It is faster to make and takes less fabric. These can literally be sewn up in less than five minutes.

Let’s start with my favorite version first…

Supply List:

a sheet of copy paper (to draft the pattern)

pencil

ruler

scissors

pan (to make the potholder fit)

material

quilter’s batting

sewing machine

thread

Length of my pattern: roughly 6″
Width of my pattern: roughly 2.5″

Step 1: Cut the pattern piece for the pot handle. My pattern is roughly 6″ long x 2.5″ wide. I folded the rectangle in half lengthwise and then cut rounded corners. This can be adjusted to fit any pot or pan handle. Just measure the handle and make adjustments as needed.

Step 2: Cut out pieces. Material = 2 pieces / Lining = 2 pieces / Batting = 2 pieces

Step 3: For the batting pieces only…trim off 1/4″ from width on top edge (edge with squared corners).

Step 4
Step 4: press

Step 4: With right sides together, pin one material piece to one lining piece with right sides together at top edge. Repeat with the other piece of material and lining. Set batting aside for now. Sew a 1/4″ seam. Press open seams.

Step 5: Place the two material/lining pieces right sides together.

Step 5: Now to sandwhich the layers. Place the two material/lining pieces right sides together.

Step 5b
Step 5b

Step 5b: Place one batting piece on top of material. Fold over lining. Hold and Flip over. Repeat this for other side. Pin in place.

Step 6

Step 6: Sew a 1/2″ seam from top around to other side of top leaving opening at top width.

Step 7: Turn and place on handle of pot.

—————————————————————————————-

Now for the more complicated version with the band trim….

If using this method, a contrasting fabric will be needed for the trim. Not much… a tiny piece… Also needed is a needle and thimble as hand sewing is required.

Step 1: Same as above

Step 2: Same as above

Step 3: Sandwhich pieces together. (Do not trim the batting in this method.) Place right sides of fabric together. On top of this place a batting then a lining. Flip and place a batting and a lining on the other material piece. Pin together.

Step 4: Sew a 1/2″ seam around from top around to other side of top leaving an opening at width end. (same as step 6 above)

Step 5: Turn.

Step 6: Pick out a contrasting fabric for trim
Step 6: Cut trim fabric double width as pattern fold in half lengthwise then fold in half widthwise and sew seam1/2″
Step 6: Place trim over pot holder with raw edges together.

Step 6: Pick out a contrasting fabric for the trim. Cut a rectangle that is the twice the width as the pattern (5″) x however wide the trim is desired to be then doubled and allow for seam allowance of 1/4″ (1 – 1 1/2″). Fold trim in half lengthwise and press with iron. Next, fold the trim in half widthwise and press with iron. Stitch a 1/2″ seam allowance on width of trim. Slip this over the pot holder with raw edges together. Pin in place.

Step 7: Hand sew trim to pot holder with raw sides together
Step 7: Turn trim to inside and pin in place
Step 7: Whip stitch trim to lining
Pot handle potholder with trim

Step 7: Hand stitch the trim in place using a 1/4″ seam allowance. Turn trim to inside and pin in place. Whip stitch the trim to the lining only covering stitching. Place on pot handle.

My pots and pans are all dressed up and ready to use. No more burnt hands for me! The best part of this DIY projcet is that the potholders take very little fabric and can be made very quickly. The fabric I used were scraps leftover from other projects, so it did not cost me anything to make them.

Be sure to check-out my previous DIY post on making potholders for pot lids as well. As always, Happy Crafting!

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out /  Change )

Google photo

You are commenting using your Google account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s